Effect of seawater on flotation separation of galena from sphalerite
Effect of pH value on galena and sphalerite flotation (C DDTC = 60 mg/L, C MIBC = 50 mg/L). Fig. 5 shows that in DI water, when the dosage of ZnSO 4 is 20 mg/L, the maximum difference in flotation recovery between galena and sphalerite was 59.40 %, and lead and zinc were most easily separated.
اقرأ أكثر
Selective depressive effect of pectin on sphalerite flotation …
The recovery of sphalerite and galena were 3% and 91% at pH 8, respectively, a better flotation index compared with that in the single-mineral flotation test. Galena and sphalerite are narrow band gap semiconductors, and a galvanic cell may be generated when they come into contact with an electrolyte(Ke et al., 2016, Wu et al., 2020).
اقرأ أكثر
Selective flotation of galena from sphalerite using a …
Abstract. An effective reagent combination plays a crucial role in the flotation separation of galena and sphalerite. In this work, potassium permanganate …
اقرأ أكثر
Selective flotation of galena from sphalerite using a …
An effective reagent combination plays a crucial role in the flotation separation of galena and sphalerite. In this work, potassium permanganate (KMnO4) was used to amplify the property difference ...
اقرأ أكثر
FLOTATION BEHAVIOR OF GALENA AND LEAD …
10, Galena flotation recovery as a function of pH at three different levels of zinc sulfate addition, KEX 1x10~3 mole per liter. ..... 24 11, Sphalerite flotation recovery as a function of pH for a collector addition of 1x10"4 mole per liter potassium ethyl xanthate (KEX) ... 26 12, Sphalerite flotation recovery as a function
اقرأ أكثر
Floc flotation of galena and sphalerite fines
The flotation of galena and sphalerite fines in the form of flocs, which is termed floc flotation, has been studied in the present work. The flocs formed through hydrophobic flocculation induced by potassium amyl xanthate (PAX) and kinetic energy input. The studies were performed on single minerals of −20 μm size by using micro …
اقرأ أكثر
Synthesis of trimethylacetyl thiobenzamide and its flotation …
1. Introduction. Galena and sphalerite are the main ore sources for industrial extraction of lead and zinc [1], [2], [3].However, galena and sphalerite are difficult to separate as they coexist with each other [4], [5], [6].With the development of high-grade mineral resources, sulfide minerals tend to be more and more "lean, fine and hybrid" [7], …
اقرأ أكثر
Synthesis of trimethylacetyl thiobenzamide and its flotation …
At present, the common method of flotation separation of galena and sphalerite is flotation of galena and depression of sphalerite or flotation of sphalerite and depression of galena [17], [18], [19]. Corresponding inorganic or organic inhibitors need to be added in this process [20].
اقرأ أكثر
The utilization of 2-phosphonobutane-1,2,4
To further confirming the depression performance of PBTCA on the flotation separation of sphalerite and galena, the flotation tests of synthetic mixture minerals were also performed. The effect of PBTCA concentration on the recoveries of sphalerite and galena are displayed in Fig. 5. Without PBTCA, it was impossible to …
اقرأ أكثر
Microbially induced selective flotation of sphalerite from galena …
The selective flotation recovery of sphalerite from a sphalerite-galena mineral mixture in the presence of intact or thermolysed B. megaterium cells after 10 cycles of adaptation to either sphalerite or galena is shown in Fig. 2.Heating the bacterial cells causes damage to many of the molecular components of the cell, leading to inactivation …
اقرأ أكثر
Flotation and surface modification characteristics of galena
The flotation tests and XPS analyses on galena, sphalerite and pyrite have been carried out in a collecting-depressing-reactivating system (hereafter referred as the CDR system). In this system, sulfide minerals were first collected and activated by the collector, and then depressed strongly by Ca(OH)2 in the strong alkaline solution, and …
اقرأ أكثر
Selective Adsorption Mechanism of Zinc Ions on the Surfaces …
The FTIR spectra of minerals (galena and sphalerite) before and after treatment with SBX are obtained to better understand the difference in flotation …
اقرأ أكثر
Lead activation of sphalerite during galena flotation
Sphalerite is generally recovered by flotation; however, it has been established that the success of this stage is affected by surface contamination with ferric iron precipitates during grinding.
اقرأ أكثر
Flotation and surface modification characteristics of …
The results of galena flotation test in the CDR system are shown in Fig. 4. Fig. 4 Influence of pulp potential on flotability of galena This shows that in the depressing process, the flotation behavior of galena is similar to that of pyrite or sphalerite. However, in the reactivating process, the flotation behavior of galena is obviously ...
اقرأ أكثر
Selective flotation separation of galena from sphalerite via …
In this work, three nitrogenous collectors DPTU, ADCT and DPTZ were used for the selective flotation of galena from galena/sphalerite mixed system. And the …
اقرأ أكثر
Improving separation of sphalerite and galena by surface …
Effect of CLS on the flotation of sphalerite and galena at different pH. Compared with CLS alone, pre-addition of H 2 O 2 can greatly reduce the dosage of CLS. A small amount of cls can depress galena and sphalerite. As shown in Fig. 5, the depression of CLS on these two minerals is significantly enhanced when H 2 O 2 is added. A small dosage ...
اقرأ أكثر
Flotation Mechanism of Sphalerite by …
Sphalerite is a common sulfide mineral, and xanthate is usually used as the collector of sphalerite flotation. In order to realize the simultaneous flotation of sphalerite- and zinc-containing oxide ores, in …
اقرأ أكثر
A reagent scheme for galena/sphalerite flotation separation: …
Flotation has been extensively used to separate galena and sphalerite. Herein, a reagent scheme comprising aerofloat collectors and Zn 2+ and SO 32− …
اقرأ أكثر
Selective flotation of galena from sphalerite using a …
In this work, an environment-friendly sphalerite depressant 1-hydroxyethylidene-1,1-diphosphonic acid (HEDP) was exploited in the flotation …
اقرأ أكثر
Selective flotation separation of galena from sphalerite via …
The primary coexisting mineral with galena is sphalerite. Hence, it is critical to selectively separate galena from sphalerite by flotation. In this work, thiourea and related derivatives as … Expand
اقرأ أكثر
Effect of seawater on flotation separation of galena from sphalerite …
Selective Flotation of Galena from Sphalerite Using a Combination of Kmno4 and Carboxylated Chitosan. Yuangan Chen B. Feng Jinxiu Peng Ziming Wang. Chemistry, Materials Science. SSRN Electronic Journal. 2022; 15. Save. Flotation separation of galena from sphalerite using hyaluronic acid (HA) as an environmental-friendly …
اقرأ أكثر
Selective flotation separation of galena from sphalerite via …
The flotation results showed that collector with more nitrogen atoms (DPTZ) offered better selectivity for the flotation separation of galena from a galena/sphalerite mixed mineral system. Separation selectivity, FTIR and XPS studies showed, in the case that collector solution environment pH value < pK a value, N atoms did not participate in ...
اقرأ أكثر
(PDF) A reagent scheme for galena/sphalerite …
Galena (PbS) is an important and abundant source of lead (Pb) metal. It often coexists with other sulphide minerals such as sphalerite (ZnS). Flotation has been extensively used to separate galena ...
اقرأ أكثر
FLOTATION BEHAVIOR OF GALENA AND LEAD …
Micro-flotation studies with galena and lead-activated sphalerite were performed to determine the depressing effect of zinc sulfate on the flotation behavior of these minerals,
اقرأ أكثر
Galena – Sphalerite Flotation & Separation …
Galena – Sphalerite Flotation & Separation Method. The problem of treating oxidized lead-zinc ores for the production of high-grade lead zinc flotation concentrates is a complex problem due to the nature …
اقرأ أكثر
Investigations of Monomineralic Flotation of Galena, Sphalerite…
Temperature variations could potentially impact flotation performance, leading to operational and economic issues. Several historical and currently operating plants across Canada have reported seasonal metal losses as one of their major challenges. Improvements in flotation efficiency at cold temperatures are important for …
اقرأ أكثر
Selective Flotation of Galena from Sphalerite Using a …
In this work, an environment-friendly sphalerite depressant 1-hydroxyethylidene-1,1-diphosphonic acid (HEDP) was exploited in the flotation separation of sphalerite and galena. The flotation ...
اقرأ أكثر
Ore mineral characteristics as rate-limiting factors in sphalerite
Two flotation tests were conducted to duplicate the experiment. Zinc sulfate (ZnSO 4) and dextrin (Dextrin Gul) were used in the copper-lead rougher flotation stage to depress sphalerite whereas potassium amyl xanthate (KAX) and triethylene glycol monobutyl ether (Nasfroth 240) were used as a collector and frother reagent, …
اقرأ أكثر
Ethyl xanthate adsorption and adsorption kinetics on lead …
Infrared attenuated total reflection spectrophotometry, UV data, microelectrophoresis and a Hallimond tube flotation cell have been used to investigate the effect of Pb(II) on the galena and sphalerite surface properties (hydrophobicity and charge of the surface), ethyl xanthate adsorption and ethyl xanthate adsorption kinetics in …
اقرأ أكثر
New collectors in the flotation of sulphide minerals: a study …
COLLOIDS AND A Colloids and Surfaces SURFACES ELS EVI ER A: Physicochemical and Engineering Aspects 122 (1997) 207-225 New collectors in the flotation of sulphide minerals: a study of the electrokinetic, calorimetric and flotation properties of sphalerite, galena and chalcocite G.S. Maier *, X. Qiu, B. Dobias …
اقرأ أكثر